Orange TKO comes as a concentrate, which can be diluted with water to handle the toughest industrial cleaning problems, but is safe enough to use in the home, around children and animals. This form also makes it very economical - just one tablespoon of TKO mixed with water, makes 24 fl. oz. of General Solution.
Use for Laundry stains and odors, Pet odors, Skunk spray, oil stains, tar, mildew, grease, Oven cleaner, Toilet, Carpet, Air freshener, Smoke on clothes, Drapes, Hardwood, Mattresses, Dishwasher, Gum, Stickers, Markers and Scuff marks.
Organic Orange TKO Pet Uses (click to view pdf)
Organic Orange TKO Removes Mildew (click to view pdf)
Organic Orange TKO Manual (click to view pdf)
Caution: Always dilute with water first. Do not use concentrated Orange TKO on plastics, fiberglass, or plexiglass!
The cleaning power lies in the seeds and peels, known as d'limonene. Orange TKO goes through a distilling process for added purity. The distilling process recovers the d'limonene from the orange peel, leaving no oily residue, and also removing acidity. Orange TKO enhances the natural emulsification properties of d'limonene and can be blended with water. Through this process, Orange TKO is not only environmentally friendly and biodegradable, it is a powerful formulation which will remove any odor or stain. A light formulation of the solution can actually sprayed on pets and plants as a bug repellent, and eliminates odors and stains.
|Material Safety Data Sheet U.S. Department of Labor
Complies with USDL Safety and Health regulations. (29 CFR 1910. 1200)
|Section 1: PRODUCT IDENTIFICATION: Degreaser/Deodorant
Orange TKO Industries International
810 - 16th Ave. NW
Calgary, AB T2M 0J9
Revision Date: 01/01/08
|SECTION II: HAZARDOUS INGREDIENTS
This product contains no ingredients which are considered to represent a health hazard as currently defined by 29 CFR 1920. 1200
This product is not a carcinogen or potential carcinogen as defined by OSHA, The NTP, or the IARC monographs.
|SECTION III: PHYSICAL DATA
BOILING POINT: 352 degrees Fahrenheit
VAPOR PRESSURE: 1 mm of HG @ 20 degrees centigrade
VAPOR DENSITY, (Air=1): 4.69
SOLUBILITY IN WATER: Emulsifies; Soluble only in trace quantities.
SPECIFIC GRAVITY, (H20=1): 0.841 @25 Degrees C./25 Degrees C.
PERCENT VOLATILE BY VOLUME: 93%
EVAPORATION RATE, (Water=1): <1
P.H.: (10% Emulsion): 4 - 6
APPEARANCE AND ODOR: Amber liquid with citrus odor.
|SECTION IV: FIRE AND EXPLOSION DATA
FLASH POINT, (method used): 120 degrees Fahrenheit, (C.C.)
FLAMMABLE LIMITS, (A.I. 302 degrees Fahrenheit): LEL-0.7; VEL-6. 1
EXTINGUISHING MEDIA: 1) Dry powder; 2) Foam; 3) C02
SPECIAL FIREFIGHTING PROCEDURES: Avoid use of water as it may spread flame.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Combustible liquid. Keep away from sparks and open flame.
|SECTION V: HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: Unknown
EFFECTS OF OVEREXPOSURE: Direct eye contact will result in irritation. Possible skin irritation with prolonged use.
EMERGENCY FIRST AID PROCEDURES:
SKIN: Wash immediately with soap and water.
EYES: Flush with water, if irritation persists, call physician.
INGESTION: Drink large volumes of milk or other liquid, call physician immediately.
INHALATION: If symptoms of overexposure and experienced, evacuate to fresh air. Consult physician if breathing is difficult.
|SECTION VI: REACTIVITY DATA
STABILITY DATA: Stable
INCOMPATIBILITY: Avoid strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: None known.
HAZARDOUS POLYMERIZATION: May occur. Polymerization catalysts such as aluminum chloride should be avoided.
|SECTION VII: SPILL OR LEAK PROCEDURES
SMALL SPILLS: Wipe up product, rinse soiled area with water down the drain.
LARGE SPILLS: Stop leak at the source and collect into a suitable container, then treat as a small spill.
Follow state and local regulations for disposal of large non-reclaimable spills.
|SECTION VIII: SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: Not normally required, but if vapor concentration becomes high, use general purpose organic vapor mask.
VENTILATION: Local exhaust should be adequate.
PROTECTIVE GLOVES: Nonporous rubber gloves.
EYE PROTECTION: Chemical splash goggles or face shield.
OTHER PROTECTIVE EQUIPMENT: Usually not required.
|SECTION IX: SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Handle as a combustible liquid. Vapors can ignite, store away from heat and open flame. Always store unused portion in original container with cap secure. Avoid temperature extremes.
OTHER PRECAUTIONS: All handling equipment should be electrically grounded. As with all chemicals, use with due care according to label instructions and precautions.
This certified [glossary]organic[/glossary] cleaning agent is 100% environmentally friendly, [glossary]biodegradable[/glossary], and [glossary]non-toxic[/glossary].
It is an emulsifier, which contains no synthetic chemicals, [glossary]petroleum distillates[/glossary], or detergents. Orange TKO contains d'limonene (made from the peel of the orange), [glossary]surfactants[/glossary], and oxygen has been added. It is 100% natural and biodegradable.
Strong enough to clean your engines and power tools, yet safe enough to spray on your bedding and use as an air freshener.
Orange TKO is an emulsifier made from the peel of the orange. D'limonene is the active ingredient that gives citrus cleaners the punch.
Through a double distillation process, d'limonene is separated from the orange oil, removing the acidity, leaving Orange TKO with a neutral pH. This double distillation process preserves the organic integrity of Orange TKO. Orange TKO is not corrosive, and leaves no residue.
Two environmentally friendly (EPA approved) surfactants are added to allow d'limonene to blend with water. Surfactants are also wetting agents, which gives TKO more cleaning strength.